Replacing your AC unit's fan motor isn't as expensive as you might think. This repair can range from $750 minimum to about $1,150 depending on your unit. Nothing to sneeze at, but also not as bad as it could be.
How Much Does an AC Fan Motor Cost? The average cost of a new condenser fan motor ranges between $300 and $700, depending on the model, your AC unit, and labor costs.
AC repair costs can vary widely, depending on the cause of the problem and the type of vehicle. On average, car AC repair costs run between about $430 and $520. However, if you need a new compressor, you can expect to spend $1,300 to $2,500 or more.
It typically takes one to four hours for the technician to replace the AC fan motor. Normally, good technicians will check for other issues during this replacement. If more problems are found, they will be repaired as well. This means that a full repair may take a little longer.
Winding insulation breakdown and bearing wear are the two most common causes of motor failure, but those conditions arise for many different reasons. This article demonstrates how to detect the 13 most common causes of winding insulation and bearing failure in advance.
The Cost of Not Replacing It
Because of how hot the system runs, running your AC with a failed fan motor could result in your compressor failing, too. The compressor is a much more expensive component, typically running $1,400-$3,000, so procrastinating on AC repair could be a very costly delay.
You'll want to consider factors like how old your AC system is, how often repairs were needed in the past and how much they cost, and the system's overall performance. If your AC system is old and repairs are becoming more frequent and costly, replacement might be the most economical and effective solution.
For large AC motors requiring rewinds and more extensive repairs, rapid repairs can also be provided with a round-the-clock service. Rotamec's AC motor repair service can be more cost effective than motor replacement. For large AC motors, repair can also be the faster option.
Your vehicle's air-conditioning not working is likely caused by a failing compressor or a freon leak. While these are the most obvious reasons for your air-conditioning not working inside your vehicle, it might be anything as simple as a bad belt or a dirty cabin air filter.
If your air conditioner is making a shrieking noise, this is an indicator of an issue with the fan motor. This sound may also be caused by a broken motor in the compressor of the condenser system. A screeching or squealing noise may also be caused by a damaged blower fan motor inside your house.
In addition to a sudden stop, these signs of blown AC fuses require your attention: Strange sounds are coming from your air conditioning unit. Your circuit breaker keeps tripping. Your unit smells like it is burning or gives off the smell of exhaust.
Less than 50% of the replacement cost: If your HVAC equipment is under 10 years old and the repair bill is less than half of the cost to replace it, a repair is most likely the right choice.
Experienced DIYers can typically handle cleaning condenser and evaporator coils, and may be able to clear a blocked condensate drain line, but it's recommended to contact an air conditioner repair professional to replace a faulty compressor or recharge refrigerant levels.
Place a multimeter across the L and N leads and set the meter to resistance. The value should start at a lower resistance, but not zero, and should quickly increase a bit and level off at a slightly higher value (this is intentionally vague, as the exact resistance values depend on the motor size).
AC motor fan replacement costs typically range from $100 to $700. If your AC is under warranty, you'll only pay labor costs. Season, part brand, and diagnostic fees influence repair costs. Original equipment manufacturer parts are often necessary for warranty.
These can be costly to fix due to being challenging to get to and expensive to purchase. Refrigerant recovery is time-consuming, typically requiring three hours or more to service. All these things make servicing an automotive air conditioner something that is beyond the skill level of the average car owner.
Warm Air from the Vents
If the compressor is fine, it will push cold air into the cabin of your vehicle. If you begin to notice warm or even hot air coming out of the vents, this is a clear indication that the compressor is not functioning properly.
A broken A/C compressor is certainly an issue and can cause problems to your car as a whole. Driving with a broken A/C compressor can harm your car's engine. Remember, each part of your car is connected. Crucial aspects of your car's A/C compressor, like the pulleys and belts, are powered by the engine.
Your AC's blower motor is responsible for moving air through your air conditioner to cool it and then pushing it back out into your home. Without this incredible component, your AC can't provide any cooling effect, no matter how much the compressor runs.
The average cost for an AC compressor is $1,200, but you might pay between $800 and $2,300 depending on your unit type and brand. On average, AC compressor costs range from $800 to $2,300, with most folks paying $1,200 for a new one.
Although AC fan motors can last 10-15 years or more, a lack of regular maintenance can shorten their lifespan.