Most homeowners will pay in the range of $200 to $400 for a refill, depending on the type and size of their HVAC unit. If you own a larger r22 unit, you may have to spend $600 or more. To break this down for you, a 25lbs unit of r410A costs anything between $100 and $175.
If you need refrigerant for your air conditioner, you'll need to contact a professional heating and cooling technician. Under EPA regulations, only a certified professional can recharge your home's HVAC system.
Depending on the type and amount you need, it's likely the cheapest serviceable part of your AC unit. The reason it costs so much is that you need a qualified person to put it in the unit, which takes time and labor, both of which are the expensive parts of the service bill.
Generally speaking, a properly maintained air conditioner can expect its refrigerant to last around 10-15 years or longer—depending on usage frequency and environmental wear and tear. To ensure your refrigerant lasts as long as possible, regular maintenance is key.
The average cost to recharge the Freon levels in an air conditioner unit ranges between $200 and $600. This number can vary, depending on the city you live in, the HVAC provider you choose, and the refrigerant levels in your air conditioner.
Refrigerant is a working chemical that runs through your car's A/C system in either a gaseous or liquid form. Causes of refrigerant leaks in your vehicle include physical damage, wear and tear over time, and escaping refrigerant even without a leak.
Steps to Check Refrigerant Levels
Turn off the air conditioner and locate the service valves. Attach the manifold gauge set to the service valves. Turn on the air conditioner and observe the pressure readings, which should be between 30-40 PSI for most systems (though some may require higher or lower pressures).
A professional AC recharge typically ranges from $150 to $300. This cost reflects the expertise required and the equipment used to ensure a proper recharge. On the other hand, a DIY recharge kit costs between $40 and $60. While this is a more affordable option, it requires careful handling to avoid issues.
If you put the newer freon in right away, your unit will rupture due to the force. However, you can convert your AC unit to handle R410A. You'll need to replace the compressor, condenser, evaporator, and likely the refrigerant tubing. If you replace all of this, your old unit will work fine with the new freon.
An AC leak will lead to warmer air from your vents over time. In most cases this can be fixed with a proven stop leak additive to seal up any leaks. When it's time for an AC recharge, turn to AutoZone.
First, check your filters and coils for dirt and debris that may be impeding airflow. Once you've cleaned the filters and coils, run the air conditioner with just the fan so that the ice accumulation can melt off. If the AC still doesn't blow cold air, it could be that refrigerant levels are too low.
You need to be aware that if your AC unit uses the CFC type of refrigerant, you will need a licensed AC technician to recharge the system in the United States. It is against the law in the U.S. for anyone not licensed to buy or use ozone-depleting CFC or HCFC refrigerants.
Refrigerant can only be sold to technicians certified under the Section 608 or Section 609 technician certification programs, where individuals may only purchase refrigerant consistent with the appliances covered by their certification.
Most systems need Freon replacement anywhere from once every two to five years from a professional HVAC Contractor. The most significant exception to this rule is when there is a leak in the air conditioning system, which decreases the amount of refrigerant in an AC unit over time.
According to PG&E, most central air conditioning systems use two to four pounds of refrigerant per ton of cooling capacity. A three-ton air conditioner would typically have six to 12 pounds of refrigerant for a proper charge.
Normally, this occurs at the location of the evaporator coil, but is not the only place a leak can stem from. If you lose enough freon from your HVAC system, your air conditioner won't work and will need servicing.
Depending on where the leak is, whether or not a leak test is needed, and what actually requires repair, an average refrigerant leak detection and repair can actually cost anywhere from $150 to $500 depending on how accessible the leak is for the technician.
Can you stay in a house with a Freon leak? While a small leak in your AC unit may not pose an immediate danger, it's essential to address the issue promptly. Leaking refrigerant can lead to inefficient cooling and higher utility bills, and prolonged exposure might cause health issues.
A Question of Supply and Demand
Even though Freon is still being produced, the supply has dwindled as producers have cut back in anticipation of lower demand. Therefore, maintenance people and air conditioning system specialists have less supply and are charging more for it.
For refrigerant leak detection and air conditioning repair you may pay anywhere from $550 to $1,600.
Unlike car refrigerant, your AC should rarely need more Freon. The coils where it flows are an enclosed space, allowing it to recirculate throughout your system. The only way your AC can be significantly low on this substance is if there is a leak in the system.