The average cost for a Blower Motor Replacement is between $342 and $362. Labor costs are estimated between $68 and $86 while parts are priced between $274 and $276. This range does not include taxes and fees, and does not factor in your unique location. Related repairs may also be needed.
Labor. Installing a new heating and air conditioner blower motor could cost around $150 to $250, with most of that coming from labor costs. HVAC technicians usually go for around $75 to $125 per hour. A blower motor replacement might take anywhere from one-and-a-half to two-and-a-half hours.
SMOKE OR SMELL WHEN DRIVING
A burned blower motor cannot exactly damage your car but you are not sure that the smoke is coming from the blower motor. Such signs indicate damage and you must tow it to a mechanic before turning the engine back on.
In general, it can take two to three hours to replace a typical blower motor. If a highly qualified technician has the part in stock, it can take as little as 1.5 hours.
Replacing the blower motor is likely the best decision if your furnace is under warranty or relatively new. It might be better to replace the furnace if it's old or has a lot of issues that require frequent repairs.
The replacement of the blower motor is common and straightforward, so most shops will perform the repair — many on the same day.
Blower motors are designed to last just as long as your furnace itself, anywhere from 10 to 20 years. Just as with any HVAC system, the better maintained and serviced your equipment is by experienced HVAC technicians the longer it will last and the fewer repairs you'll face.
A defective ground wire or ground wire connection and an open circuit in the power-side circuit (including the fuse, wiring, and fan switch) are the most common reasons why a blower motor fails.
You can reasonably expect to find replacement blower motors at Parts Geek from $20 to $120, while the majority of these motors cost between $190 - $275 when you buy them from other parts stores. Costs for this part depend on several factors: Compactness of design. Levels of blower precision.
Blower Motor Resistor Test
Typically, if the fan will work on some speeds but not on others, the resistor is suspect. Okay, let's say there's no melting going on, but your fan doesn't work on all speeds. Typically, if the fan will work on some speeds but not on others, the resistor is suspect.
Your car's HVAC blower motor is not only necessary for the operation of your air conditioner. Without a functioning blower motor your engine runs the risk of overheating.
Some of the reasons a blower motor might fail are overheating, and excessive moisture. When dust, dirt, and debris build up, it can cause the windings and bearings to burn up more quickly.
If your blower motor is not functioning properly, it can't circulate air through your AC system, causing the evaporator coil to become too cold and eventually freeze up.
The average costs for common A/C car repair services are: A/C Repair – $384 to $445. A/C Compressor Replacement – $1,546 to $1,705. A/C Recharge – $239 to $281.
If the blower motor is going bad, it will struggle to operate the fan. The result will be weak airflow coming from the vents inside your living spaces. This airflow issue can be one of the main symptoms that indicate the component needs to be replaced.
The blower is supposed to last the entire lifetime of your car. However, situations vary and some climates require the fan to be used too often. Many car owners find themselves having to replace the blower after five years. The quality of the motor used to power the blower matters.
On average, people can expect to pay in the $5,000 to $10,000 range for an engine replacement, but your experience may vary. Why? Engine replacement costs largely hinge on two factors: The type of vehicle you drive.
On some platforms, a faulty blower motor relay will cause the blower not to work at all, which means there will be no airflow from the A/C. On others, the blower won't work on “high blow” but all the other speeds will work. The blower motor relay fails because it regularly deals with high current loads.
Faulty Blower Motor
If your blower motor is experiencing some issues, you may hear a high-pitched squeal or whistling sound. You may also experience rattling and loud screeching noises. The motor blower pushes warm air out of the furnace through the ducts into your home.
Just about every car has blower fans that circulate air from the heating and cooling system; many vehicles have two or more fans in the cabin. High-end vehicles have fans built into the seats for cushion ventilation and heat distribution.
A blower motor replacement can cost between $150 and $2,000 depending on the size of the motor, single or variable speed, accessibility and difficulty of installation, and contractor labor rates.
Strange Rattling, Clanking, or Screeching
One of the first signs you may notice when there's an issue with the blower motor is a strange noise coming from the indoor unit or air handler. Different noises will indicate different problems.
Overheating is one of the most frequent occurrences that can render the blower motor inoperative. If the motor has overheated, it may shut itself down to prevent damage. You should keep your HVAC clean and clear of any blockages or debris to avoid overheating and maintain efficiency.